When do i need a pilot vehicle

The escort shall be a front escort for highways with only one lane in each direction and a rear escort for highways with two or more lanes in each direction. This requirement is in addition to, and not in place of all other escort requirements. In some cases a beacon light may be substituted. Escorts may also be required at lesser dimensions if deemed necessary for the safety of the motoring public.

A light bar may be allowed in lieu of an escort vehicle on divided highways when expressly stated on the permit. The light bar attachment must comply with the following: 1. Must have a left and right rotating amber, yellow or flashing light of sufficient size to be seen at a distance of not less than '.

Light bar attachment shall be mounted on the rear of the load at a height sufficient to be seen clearly by traffic to the rear.

Some routes may impose additional escort requirements. Excessive weight vehicles may require police escorts. Escorts may also be required because of route limitations, traffic conditions, or unusual vehicle configuration.

The Commissioner of Motor Vehicles may require two or more escort vehicles on a case-by-case basis. Adequate hearing, vision, and physical mobility are especially important for safe traffic control operations. There is wide flexibility regarding the size and type vehicle to be used as an escort vehicle. Some states require that escort vehicles must weigh at least 2, pounds or be at least quarter-ton pickup trucks. This requirement could rule out panel trucks or vans.

Many states also require warning flags mounted on the escort vehicles. Depending on the state, either two or four flags are required.

Some states require flags that are 12 inches square while other require 18 inches square. Most states will accept safety markings that exceed their requirements. For example, inch square flags would be acceptable if the state required only inch-square flags. Tall Loads Move the slider to see an interactive animation. Also, a height or measuring pole is required if the load exceeds 14 feet high above the road surface.

The height pole must be mounted on the lead vehicle. Moving any over-dimension load is a team event. Oversize Regulations By State. Email: [email protected]. Move the slider to see an interactive animation.

British Columbia. District of Columbia. New Brunswick. New Hampshire. North Carolina. North Dakota. Rhode Island. South Carolina. South Dakota. West Virginia. Simplify Your OD Permits Automatically organize all your permits in one simple system Process, send and orginize billing for your permits.